RECALLS

2004 Volkswagen Touareg V10 TDI

Select Different Vehicle

3 Recall Notices

These recall notices may not apply to all vehicles. Please contact your dealer for more details or contact the National Highway Traffic Safety Administration's Auto Safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Campaign Number: 04V592000 Date: 2004-Dec-15

Component: Seat Belts

Defect Summary: CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.

Consequence Summary: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.

Corrective Summary: DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.

Campaign Number: 04V233000 Date: 2004-May-19

Component: Seat Belts: Rear

Defect Summary: ON CERTAIN SPORT UTILITY VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT MAY HAVE BEEN INSUFFICIENTLY RIVETED.

Consequence Summary: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Corrective Summary: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE BELT BUCKLE. OWNER NOTIFICATION BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

Campaign Number: 03V266000 Date: 2003-Jul-25

Component: Electrical System: Wiring

Defect Summary: ON CERTAIN SPORT UTILITY VEHICLES, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED DURING ASSEMBLY. AN IMPROPERLY ROUTED TPMS WIRING HARNESS MAY CONTACT THE PARKING BRAKE CABLE SPRING.

Consequence Summary: IF THIS HAPPENS, THE TPMS WIRING CIRCUIT COULD BE INTERRUPTED, RESULTING IN AN INOPERATIVE TPMS, AND CAUSING A SHORT-TO-GROUND CONDITION THAT COULD POTENTIALLY RESULT IN A FIRE.

Corrective Summary: DEALERS WILL INSPECT THE TPMS WIRING HARNESS ROUTING AND, IF NECESSARY, CORRECT THE WIRING HARNESS ROUTING. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT VWOA AT 1-800-893-5298.