RECALLS

1989 BMW 525 i

Select Different Vehicle

5 Recall Notices

These recall notices may not apply to all vehicles. Please contact your dealer for more details or contact the National Highway Traffic Safety Administration's Auto Safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Campaign Number: 98V178000 Date: 1998-Aug-04

Component: Engine And Engine Cooling: Cooling System

Defect Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.

Consequence Summary: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.

Corrective Summary: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.

Campaign Number: 97V131000 Date: 1997-Aug-19

Component: Vehicle Speed Control

Defect Summary: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.

Consequence Summary: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.

Corrective Summary: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

Campaign Number: 94V066000 Date: 1994-Apr-11

Component: Fuel System, Gasoline: Delivery: Hoses, Lines/piping, And Fittings

Defect Summary: FEED FUEL HOSES CAN HARDEN AND "SET" OVER TIME, ALLOWING A SEEPAGE OF FUEL AT THE CONNECTION BETWEEN THE HOSE AND THE ENGINE FITTING. THE CLAMP USED TO HOLD THE HOSE TO THE FITTING IS UNABLE TO COMPENSATE FOR THE HARDENING OF THE FEED FUEL HOSE.

Consequence Summary: FUEL SEEPAGE BETWEEN THE FEED FUEL HOSE AND THE ENGINE FITTING CAN RESULT IN FREE FUEL IN THE ENGINE COMPARTMENT, WHICH COULD RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.

Corrective Summary: A REDESIGNED FEED FUEL HOSE AND HOSE CLAMP WILL BE INSTALLED TO ALLEVIATE THE FUEL SEEPAGE.

Campaign Number: 92V174000 Date: 1992-Dec-02

Component: Electrical System: Fuses And Circuit Breakers

Defect Summary: THE 80-AMPERE FUSIBLE LINK LOCATED IN THE ENGINE COMPARTMENT CAN DEVELOP MECHANICAL WEAKNESS DUE TO AGING AND THERMAL STRESSES, AND CAN BREAK.

Consequence Summary: IF THE FUSIBLE LINK BREAKS, THE TOTAL VEHICLE ELECTRICALSYSTEM WOULD BE INTERRUPTED BY THE OPEN CIRCUIT. ALL ELECTRICAL SYSTEMS WOULDBE INVOLVED, AND THE ENGINE WOULD NOT START, OR WOULD STOP, IF RUNNING. THISWOULD RESULT IN LOSS OF POWER TO THE VEHICLE WITHOUT PRIOR WARNING, LOSS OFHAZARD WARNING LIGHTS, LOSS OF LIGHTS AT NIGHT AND POSSIBLY A VEHICLE ACCIDENT.

Corrective Summary: REROUTE THE ELECTRICAL CABLES IN THE ENGINE COMPARTMENT TO REDUCE THE CURRENT FLOW THROUGH THE FUSIBLE LINK, AND REPLACE THE OLD FUSIBLE LINK.

Campaign Number: 90V016000 Date: 1990-Jan-30

Component: Seat Belts: Front: Buckle Assembly

Defect Summary: UNDER CERTAIN CONDITIONS, FRONT SEAT CENTER, FOLD-DOWN ARM REST MAY CONTACT THE SAFETY BELT BUCKLE, CAUSING DAMAGE TO THE RELEASE BUTTON AND PREVENTING THE BELT TONGUE FROM LATCHING WHEN BUCKLING UP.

Consequence Summary: OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND COULD BE INJURED IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.

Corrective Summary: REPLACE FRONT SEAT SAFETY BELT BUCKLES WITH SHORTER VERSION THAT WILL NOT CONTACT THE ARMRESTS. NOTE: OWNER NOTIFICATION DATE; 2/90 IS PREPARED IN DRAFT FORM.